J Allergy (Cairo)JAJournal of Allergy1687-97831687-9791Hindawi Publishing Corporation21747869312495210.1155/2011/682574Review ArticleIndustrial Fungal Enzymes: An Occupational Allergen PerspectiveGreenBrett J.*BeezholdDonald H.Allergy and Clinical Immunology Branch, Health Effects Laboratory Division, National Institute for Occupational Safety and Health, Centers for Disease Control and Prevention, Morgantown, WV 26505-2888, USA*Brett J. Green: dox6@cdc.gov
Occupational exposure to high-molecular-weight allergens is a risk factor for the development and pathogenesis of IgE-mediated respiratory disease. In some occupational environments, workers are at an increased risk of exposure to fungal enzymes used in industrial production. Fungal enzymes have been associated with adverse health effects in the work place, in particular in baking occupations. Exposure-response relationships have been demonstrated, and atopic workers directly handling fungal enzymes are at an increased risk for IgE-mediated disease and occupational asthma. The utilization of new and emerging fungal enzymes in industrial production will present new occupational exposures. The production of antibody-based immunoassays is necessary for the assessment of occupational exposure and the development of threshold limit values. Allergen avoidance strategies including personal protective equipment, engineering controls, protein encapsulation, and reduction of airborne enzyme concentrations are required to mitigate occupational exposure to fungal enzymes.
1. Introduction
In the United States, the 2010 civilian workforce accounted for 139 million people [1] who spend up to a quarter of their lifetime and half of their waking lives at work [2]. With changes in the global market, particularly with the rise of biotechnology, new occupational hazards have emerged. Approximately, 200 biotic (organisms or particles of viral, prokaryote, or eukaryote origin) and an even greater number of abiotic (physical and chemical) agents have been associated with adverse health outcomes. In certain occupational settings, particularly those engaged in handling purified microbial proteins in baking and manufacturing sectors, workers are at increased risk of becoming sensitized and developing respiratory disease.
Occupational asthma (OA) is the most common respiratory disease reported in the workplace [3–8]. OA has been defined as either irritant induced or immune mediated [6, 7]. Immunologically mediated OA accounts for approximately 90% of cases [9], but the severity of disease is dependent on the concentration, route, agent of exposure, and the latency period [6, 7]. Both high- and low-molecular-weight antigens can induce OA, but the immunological mechanisms are distinctly different. High-molecular-weight allergens are generally proteins that are greater than 5 kDa, and production of immunoglobulin E (IgE) results in the release of mediators from mast cells and eosinophils [6, 7].
More than 250 high-molecular-weight allergens that induce OA have been identified [4, 6, 7]. Many are derived from animals or plants, and exposure usually involves mixtures of many proteins [4, 6]. Occupations where high-molecular-weight allergens have been characterized include seafood processing (tropomysin), dairy, poultry, citrus, greenhouse, baking, healthcare (latex), pharmaceutical (drugs), and detergent manufacturing (fungal enzymes) [6]. Some of the best examples of high-molecular-weight occupational allergens are the fungal enzymes. They are particularly suited for study because they are often used as purified preparations in baking, food, detergent, textile, and pharmaceutical industries [6, 10]. In this paper, we will focus on the fungal enzymes as model high-molecular-weight allergens in industrial settings and describe the main enzymes that have been associated with occupational sensitization and asthma. Identification of emerging fungal enzymes in manufacturing and biotechnology industries is discussed as well as new methods to detect and quantify fungal enzymes in the occupational environment. Methods to avoid fungal allergens in the workplace are additionally covered.
2. Fungal Enzymes in Occupational Disease
The industrial utility of fungi has been well known since antiquity. In addition to the role of fungi as saprophytes in the environment, many species have commercial use, for example, mushrooms as food sources, ingredients in food preparation (cheese flavoring Penicillium roqueforti), alcoholic fermentation, and the conversion of sugars in bread dough to carbon dioxide (Saccharomyces cerevisiae). In Asia, Aspergillus oryzae is an essential ingredient for the production of soy sauce and the fermented drink, sake. Rhizopus spp. secrete a wide variety of enzymes including cellulolytic, proteolytic, lipolytic, and pectinolytic enzymes that are used in the production of various foods such as Tempe from Indonesia [46]. Rhizopus oryzae has also been identified as a biocatalyst for biodiesel fuel production [47]. Other fungi such as Yarrowia lipolytica have more recent applications in the biodegradation of industrial products [48]. Advances in industrial enzymology following World War II have enabled researchers to identify and utilize various enzymes and proteases that fungi produce to break down carbohydrate and lignin containing plant material in the environment [49]. To date, close to 200 fungal enzymes have been purified from fungal cultures and the biochemical and catalytic properties characterized [10, 50]. These enzymes have great utility in pharmaceutical, agricultural, food, paper, detergent, textile, waste treatment, and the petroleum industries.
Industrial fungal enzymes are high-molecular-weight proteins that are catalysts [10, 49]. A description of the common enzymes used in various industries is presented in Table 1. The most widely used enzymes of occupational importance are derived from the genus Aspergillus and include α-amylase, xylanase, and cellulase. A summary of the proteomic and immunologic properties of these enzymes is presented in Table 2. Other enzymes are also utilized from rhizosphere fungal species belonging to the genera Rhizopus and Humicola (Table 2). These enzymes usually have intracellular or other functional roles associated with apical hyphal growth. It is uncommon for individuals in the general population to be exposed and sensitized to these antigens. In fact, in the general population, the prevalence of sensitization to fungal enzymes has been reported to be as low as 1% and as high as 15% [22, 51]. However, in the occupational environment, workers that handle purified fungal enzymes are at an increased risk of becoming sensitized to enzymes [10, 23, 24, 42, 52–56]. This is especially the case for workers whose occupation requires debagging, sieving, weighing, dispensing, and mixing enzymes [24, 53–56]. Eight-hour time-weighted average exposures demonstrate that occupations weighing the enzyme preparations have the lowest average exposure compared to those workers that sieve [24]. These workers are often exposed to levels of dust that exceed 4 mg m−3, the threshold limit value (TLV) for inhalable dust [57]. For other industrial environments that use lipase and cellulose in production, occupational exposure is highest in production areas and laboratories [42].
Adverse health effects associated with enzyme exposure are well characterized in the baking industry. In some countries, bakery exposures to enzymes are one of the leading causes of occupational allergy [58]. Fungal enzymes are commonly used as baking additives to improve the dough, increase shelf life, and decrease production time [19, 49, 59]. Airborne concentrations ranging from 5.3 ng m−3 to 200 ng m−3 have been reported in occupational environments [12, 59, 60]. Occupational sensitization to fungal enzymes was first reported by Flindt [61]. Later, Baur et al. [62] demonstrated IgE sensitization in workers handling these products. Since the original study, fungal enzymes have been identified as potent allergens in the occupational environment [25, 26]. Prevalence of sensitization to Aspergillus enzymes ranges from 8% for glucoamylase [13], 11% for xylanase [13], 13% for cellulase [13], and up to 34% for α-amylase [19, 27]. Sensitization to α-amylase in bakery workers results in decreased peak expiratory flow [63–66] and OA [20, 28, 67]. In one report, workers exposed to fungal enzymes induced an immediate bronchospastic reaction [49]. In the United States, the prevalence of work-related wheeze, runny nose, frequent sneezing, and specific IgE to fungal enzymes was significantly higher among highly exposed workers [68]. However, other irritant-induced mechanisms associated with high total dust levels have also been reported in a cohort of British bakers [29, 56]. To date, atopy has been hypothesized to be an important risk factor for OA to fungal enzymes.
Occupational exposure to enzymes has been demonstrated in other industries including manufacturing [41, 53, 69], pharmaceutical [25, 38], food processing [70], animal feed, and biotechnology [43]. Like in baking environments, workers handling or in direct contact with fungal enzymes and with a history of atopy are at increased risk of becoming sensitized [10, 23, 24, 42, 52–56]. Sensitization to proteolytic enzymes has also been demonstrated in the manufacture of detergents [53, 71]. In the future, additional uses for fungal enzymes in industrial environments will be identified. Recent examples include the use of α-amylase and glucoamylase for the production of ethanol in the biofuel industry [72, 73]. If proper methods of exposure prevention are not followed and exposure is not monitored in these industries, it is possible that new groups of workers will suffer adverse health outcomes and become sensitized to enzymes. In the following sections we describe the major fungal enzymes, prevalence of sensitization, and occupational environment that they are most likely to be encountered.
Fungal amylase is the most well-characterized fungal enzyme used in the occupational environment. Originally discovered by Takamine in 1884 [49], bakers have used α-amylase as a supplement to cereal flour to improve carbohydrate fermentation by yeasts and ultimately the quality of the bread [49]. α-amylase cleaves long-chain carbohydrates into simpler sugars including maltose [49]. Derived from A. oryzae, α-amylase is a 478 amino acid glycoprotein with a molecular weight of 53 kDa (Table 2; [6]). Occupational sensitization to α-amylase was first reported by Flindt [61] and has subsequently been identified as an allergen in baking [74], pharmaceutical [25], animal feed [12], and biotechnology industries [43]. The allergen was originally designated Asp o 2 by the International Union of Immunological Societies (IUIS) Allergen Nomenclature Subcommittee but now has been redesignated Asp o 21 [27]. Since this preliminary work, α-amylase has been identified as one of the principle sensitizers in large-scale bakeries [24, 56]. The prevalence of sensitization among bakers is variable and ranges from 0.9% to 34% [13, 18, 19, 21, 23, 24, 27–35, 54, 66, 67, 75]. Concentrations as high as 40 ng m−3 have been reported in baking environments [60]; however, α-amylase concentrations in the low ng m−3 range have been associated with an increased frequency of sensitization [58].
The most common tasks associated with α-amylase exposure involve dispensing, sieving, weighing and mixing [55, 56, 60]. Exposures that exceed the maximum exposure limit for flour dust in the United Kingdom were identified in mixing, weighing [54], and dispensing operations [55]. The prevalence of sensitization to α-amylase is 9.9 times greater among workers in high-exposure categories compared to those workers in low-exposure categories [55]. Aerosolized particle size distribution analysis in baking environments demonstrated that workers are exposed to α-amylase particles within the inhalable size fraction [60]. OA is commonly identified in workers sensitized to α-amylase. After bronchial provocation with α-amylase, between 16 and 100% of sensitized workers were found to give a positive immediate response depending on the study [25, 35, 49]. Nasal provocation with α-amylase in skin prick test (SPT) positive workers also induced rhinitis [26]. Furthermore, positive associations between α-amylase SPT and work-related respiratory symptoms have been identified [23]. Interestingly, heating α-amylase has been shown to reduce enzymatic and allergenic activity of the enzyme [76]. Potential sensitization of bakers' family members due to α-amylase associated with clothes, shoes, and bakery textiles has also been reported by Vissers [77].
3.2. <italic>γ</italic>-Amylase
γ-amylase or glucoamylase is primarily obtained from A. niger, A. awamori, and R. delemar. Glucoamylase is used as a dough additive by bakers, often in association with α-amylase. The enzyme is also used in the production of high-glucose syrups [46]. Glucoamylase has a molecular weight of 68 kDa (Table 2) and can remain functionally active at elevated pH. Glucoamylase exposure has been primarily reported in baking occupations [10, 13, 18]; however, occupational exposure has also been reported in fruit and salad processing [52]. Sen et al. [52] demonstrated that three workers with shortness of breath, chest tightness, and wheeze had specific IgE to glucoamylase. Quirce et al. [18] also demonstrated positive SPT to glucoamylase in all tested subjects (n = 4); however, only three of the four patients elicited an early asthmatic response following bronchial provocation. Airborne glucoamylase was shown in 9% of air samples from a bakery [59], and median levels were 10.3 ng m−3. Moderate allergenic cross-reactivity has also been reported between glucoamylase and α-amylase [18].
3.3. Cellulase, Xylanase, and Hemicellulase
Cellulases are enzymes that hydrolize cellulose into glucose and are primarily used in the pharmaceutical, baking, detergent, and textile industries [6, 78]. Cellulase has been purified from several rhizosphere fungi including A. niger and Trichoderma viride [49], as well as Humicola insolens [41]. The molecular weight of cellulases ranges from 22 to 45 kDa (Table 2). Cellulases derived from these fungi are used in baking to break up roughage in dough and as a digestive aid in the food industry [13, 79, 80]. The first case of OA caused by cellulase was reported in 1981 in a plant pathologist [49, 81], and later these findings were confirmed in two pharmaceutical workers [80], four laboratory workers [14], and two bakers [49]. In each of these studies, the workers had specific IgE to the cellulase antigens. In 171 German bakers, the prevalence of sensitization to cellulase was 13% [13]. Airborne concentrations of cellulase have been quantified using a modified dot blot technique and were <180 ng m−3 in a flour mill, crisp bread factory, and a bakery [82]. OA has also been reported to cellulase in the baking industry [83] as well as from H. insolens used in the detergent industry [41].
Endo 1, 4-beta-D-xylanase and beta-xylosidase are major enzymes involved in xylan hydrolysis [13]. Collectively termed xylanases, these enzymes are a type of hemicellulase that breaks down hemicelluloses, a major component in plant cell walls [13]. Besides α-amylase, xylanases are the next most frequently used enzymes in the baking industry to remove pentosans from bread and increase bread volume [13, 49]. The prevalence of IgE sensitization to hemicellulase was reported to be 8% [19] and 11% for xylanase [13]. Sander and colleagues [13] found that 7 of 8 bakers had serum IgE to a 105 kDa protein in a xylanase ingredient. This protein was identified using mass spectrometry to be beta-xylosidase derived from A. niger. The allergen was designated Asp n 14 by the IUIS Allergen Nomenclature Subcommittee (Table 2). Airborne concentrations of xylanase have been reported to be <40 ng m−3 in a flourmill and crisp bread factory [82]. Concentrations as high as 200 ng m−3 were also reported in a bakery, but these values were associated with the natural xylanase activity of wheat [82]. Case reports have verified xylanase sensitization and the presence of an IgE mechanism in respiratory disease [15, 79]. OA has also been reported to xylanase in the baking industry [83], and in a case report, a baker had an immediate asthmatic response following inhalation challenge [15]. Cross-reactivity between cellulase and xylanase has been reported to be in the range of 80–90% but no cross-reactivity has been shown with α-amylase [13, 14]. Similarly, workers can also be monosensitized to cellulase and xylanase without concomitant sensitization to α-amylase [83].
3.4. Lactase
A. oryzae lactase is a high-molecular-weight protein that is involved in the hydrolysis of the disaccharide, lactose. Lactase is used in the pharmaceutical industry to develop dietary aids for patients intolerant to lactose. In a cross-sectional study of United States pharmaceutical workers, Bernstein and colleagues [38] identified 29% of lactase-exposed workers to have positive SPT response to lactase. Workers with a positive SPT were nine times more likely to have respiratory symptoms than workers with a negative SPT [38]. Interestingly, atopy was not associated with the development of respiratory symptoms. Occupational sensitization to lactase has been reported in workers formulating and packaging gastrointestinal consumer products [39]. In inhalational challenge studies conducted by Laukkanin and colleagues [40], lactase was identified to induce occupational IgE-mediated respiratory sensitization. Interestingly, lactase exposure has also been identified to cause contact skin reactions [40].
3.5. Lipase
Lipase is an essential catalyst that digests water-insoluble lipids. A. oryzae and R. oryzae lipase are used because of low extraction costs, thermal and pH stability, substrate specificity, and activity in organic solvents. Lipase is predominantly used in the manufacture of laundry detergents and in baking; however, other newer applications have been developed. For example, Candida antarctica lipase has recently been used as a biocatalyst for the biofuel industry [84]. The incidence of occupational sensitization to lipase, in industrial settings is understudied. In a preliminary analysis of detergent manufacturing workers, 3 workers were found to be sensitized to lipase and bronchial provocation tests provoked a reproducible asthmatic response [41]. A recent case study of a pharmaceutical manufacturing worker also demonstrated sensitization to fungal lipase derived from R. oryzae but not A. oryzaeα-amylase [44].
3.6. Phytase
A. niger and R. oligosporus produce phosphatase that catalyzes the hydrolysis of phytate to lower-order phosphate esters [16]. Termed phytase, this enzyme enhances phosphate bioavailability in the digestive tract and has been utilized in the animal feed industry during the last two decades [17]. Phytase accounts for 0.1–1% of total extractable protein from A. niger [17]. 3-phytase B derived from A. niger is an 84 kDa protein that has been designated Asp n 25 by the IUIS Allergen Nomenclature Subcommittee (Table 2). Allergic sensitization to phytase has been reported in animal feed factory workers (7–90%), and sensitization is highest at sites where phytase is handled in powdered form [16, 17, 69, 85]. In a cross-sectional study of 53 technical center workers that produced A. niger phytase, 52% of workers in the high-exposure group and only 10% in the low-exposure group were sensitized to phytase [16]. Personal exposure to phytase has been shown to exacerbate OA, and inhalation challenge tests produced immediate asthmatic response [86]. It has been proposed that phytase is highly sensitizing and that direct contact should be avoided in this industry [16].
3.7. Enzymes Used in Health Care Settings: Biodiastase and Flaviastase
Fungal enzymes have a number of applications in the healthcare environment. Fungal enzymes derived from A. niger are used in powdered form with other enzyme extracts by pharmacists to prepare digestive powders. Biodiastase and Flaviastase are two examples of fungal enzymes that have been associated with sensitization in hospital workers and pharmaceutical workers handling these products [10, 12–21, 23–35, 38–44, 51–88]. To date, health effects in workers exposed to these enzymes remain poorly characterized.
3.8. EPg22 Protease: Aspartic Protease
The aspartic proteases produced by Rhizomucor miehei and Cryphonectria parasitica are utilized in almost half of the cheese production operations throughout the world [46]. The proteases assist in milk clotting and facilitate a change in cheese properties by hydrolyzing certain peptide bonds. Occupational exposure to these proteases has been associated with occupational sensitization in a rennet production plant [11]. Specifically 29% and 6% of workers had a positive skin prick test (SPT) to R. miehei and C. parasitica aspartic protease extracts, respectively [11]. Other novel enzymes with potential application in the food processing industry have been identified. Pg222 is a novel extracellular protease produced by P. chrysogenum (Pg222). The enzyme was isolated from dry-cured hams and was found to have a broad range of applications in industries that produce dry-cured meat products [89]. Although no occupational sensitization has been reported to this enzyme, it demonstrates that the introduction of any new enzyme could potentially represent an occupational hazard.
4. Emerging Occupational Fungal Enzyme Exposures
The utility of fungal enzymes to degrade xenobiotics and organic compounds in the industrial sector continues to be recognized [46]. Fungal enzymes are now being used for a variety of purposes across many different industries. Improved biochemical and molecular technologies have enabled the production of other potentially allergenic proteins [14]. According to Baur [10], more than 186 commercial enzymes were produced in the European Union in 2001, and many of these were produced by recombinant technology or had been genetically engineered. Table 1 provides a summary of the major fungal enzymes that are utilized in industrial settings. All of the aforementioned enzymes that are listed in Table 1 have been identified to be potent allergens in the workplace; however, the ability of the other listed enzymes to cause adverse health outcomes following occupational exposure remains unclear.
Several of the enzymes presented in Table 1, not identified as occupational allergens, have been identified as allergens associated with environmental bioaerosols. Catalase, a fungal enzyme utilized in hygiene products, pharmaceuticals, and textiles, has been identified as an allergen in the entomopathogenic fungus, Metarhizium anisopliae [90]. Pectinase is used in brewing and wine production, food processing, and paper industries and allergy to pectinase has been associated with occupational exposure [91]. Esterase has been identified as an allergen in Hevea brasiliensis (natural rubber latex) [92]. Beta-glucanase is used to improve the nutritional yield of animal feeds, and occupational exposure has been shown in a case study to significantly reduce forced vital capacity and forced expired volume in 1 second (FEV1) [86]. The worker in this case study was also SPT positive and had specific IgE to beta-glucanase [86]. In the biotechnology and pharmaceutical industries, glutathione-S-transferase (GST) has a number of applications. GST is an approximately 26 kDa protein that has been identified as a major Alternaria alternata allergen and is highly conserved across fungi [45, 93, 94]. The IUIS Allergen Nomenclature Subcommittee has designated this allergen Alt a 13 [93, 94]. Interestingly, alpha-galactosidase has been associated with delayed anaphylaxis, angioedema, or urticaria in sensitized patients following the ingestion of beef, pork, or lamb [95]. Although the role of alpha-galactosidase and these other enzymes following occupational exposure remains unclear, these studies provide preliminary insight into the possible potency of these allergens in industrial environments.
5. Immunodiagnostic Detection Methodologies
Occupational allergic sensitization to fungal enzymes is diagnosed clinically using available in vivo SPT reagents, or in vitro assays such as Phadia ImmunoCap [7]. However, SPT reagents for most of the fungal enzymes used in industrial settings are not commercially available and have to be either custom ordered or prepared individually by the investigator. Methods for SPT extract preparation that are used by investigators in the field have been previously described by Quirce et al. [49]. In vitro diagnostic tools that can quantify the amount of specific IgE to an occupational allergen are not readily available except in research laboratories where investigators prepare their own inhibition or radioallergosorbent enzyme-linked immunosorbent assay (ELISA) to quantify specific IgE [36, 49]. To date, α-amylase (k87) is the only fungal enzyme available on the Phadia ImmunoCap testing panel. To confirm OA caused by fungal enzymes, bronchial provocation tests can be undertaken to document immediate or late-phase responses to fungal enzymes [36, 49]. Positive immediate response criteria used in workers exposed to enzymes include a greater than 20% fall in FEV1, whereas a late-phase response has been considered positive when there is a 30% or greater fall in peak expiratory flow rate [49]. However, there are several limitations with bronchial provocation tests that should be considered; these are discussed in detail by Peden and Reed [7].
In order to better understand the relationships between occupational fungal enzyme exposure and clinical symptomology, accurate information on the distribution and quantity of the fungal enzyme in the occupational environment will be required. Immunodiagnostic methods that utilize antibodies could provide standardized methods for quantifying fungal enzyme biomarkers in a variety of occupational environments. Following validation and interlaboratory comparison, the assays could be used for exposure assessment to determine the existence of exposure-response relationships [58, 96]. This information is critical for the development of future threshold limit values (TLVs) and other occupational standards.
Several antibodies and immunodiagnostic methods have been produced to detect industrial fungal enzymes, in particular α-amylase. These methods have been employed in field investigations and used to quantify the concentration of the enzyme from collected air samples. Bogdanovic et al. [97] used an enzyme immunoassay with a sensitivity of 25 pg/mL to quantify α-amylase in airborne and surface dust samples collected from five bakeries. In the same study, a lateral flow immunoassay for α-amylase was compared to the reference enzyme immunoassay. The sensitivity of the lateral flow assay was 1–10 ng/mL, and extracts with >5 ng/mL allergen were positive in the lateral flow assay [97]. In a study of 507 personal air samples, Houba and colleagues [60] used a rabbit IgG capture immunoassay to quantify α-amylase in specific baking job category. Concentrations of α-amylase up to 40 ng m−3 were quantified, and workers directly involved with dough preparation had the highest exposures [60]. Using the same rabbit IgG sandwich assay, Nieuwenhuijsen et al. [55] identified dispensing and mixing areas to have the highest α-amylase exposure in British bakeries and flour mills. Two monoclonal antibody- (mAb-) based ELISAs have been developed for the detection of α-amylase in the occupational environment. Assay sensitivities ranged from 0.2 ng/mL [98] to 0.6 ng/mL [99]. A quantitative mAb-mediated dot blot assay has also been previously described for cellulase and xylase; the detection limits reported were 20 ng m−3 and 2 ng m−3, respectively [82]. mAbs to other fungal enzymes, such as xylanase have been produced and reported in the literature [100]. Similarly, the detergent industry has produced antibodies and immunoassays for several common fungal enzymes and these have been utilized in industrial hygiene safety programs to mitigate worker exposures [101–103]. Unfortunately, for many other fungal enzymes presented in Table 1, there are no commercially available antibodies to enable quantification in the occupational environment. The development of fungal enzyme-specific mAbs in combination with immunodiagnostic techniques will further our knowledge of the exposure-response relationships in occupational environments. Using these methods will also help enable the development of standards and focus on the prevention of sensitization in heavily contaminated work environments.
6. Allergen Avoidance and Directions for the Future
Exposure to fungal enzymes, in particular α-amylase, is a considerable health risk in a number of industries. Cross-sectional studies have shown that processing workers in high-exposure categories who handled fungal enzymes are up to ten times more likely to be sensitized to fungal enzymes than workers in the low-exposure category [55]. Highest concentrations of enzymes in the inhalable fraction were encountered among workers located in dispensing, mixing, weighing, and sieving occupations [54–56, 60]. Airborne concentrations as high as 40 ng m−3 and in some cases even higher (200 ng m−3) have been reported for sensitized workers located in these handling areas [12, 55, 60]. Concentrations in the low ng m−3 range have been associated with an increased frequency of sensitization [58]. For other fungal enzymes, such as phytase, similar findings have been reported [16].
The continued utilization of other previously overlooked enzymes as well as new genetically engineered enzymes in various industries will continue to provide diagnostic challenges, even for the most seasoned occupational medicine professional. It is likely that new cases of occupational allergic disease will emerge following exposure to fungal industrial enzymes during the next decade. In response, identification of exposure-response relationships will be critical for the development of TLVs and occupational exposure levels. However, this will depend on the development of suitable diagnostic antibodies and immunoassays. Currently, subtilisin, a sereine endopeptidase derived from Bacillus subtilis, is the only enzyme for which the American Conference of Governmental Industrial Hygienists (ACGIH) has established a TLV value (60 ng m−3). The European Union Directive also classifies the fungal enzymes cellulase and α-amylase with the risk phrase R42 (may cause sensitization by inhalation) [10]. There are currently no consensus standards for other industrially utilized fungal enzymes.
As a precautionary measure, it has been concluded that all enzymes should be regarded as an allergen that can exacerbate respiratory sensitization in susceptible populations [10, 59]. Baur [10] has further proposed that all enzymes should be classified as R42 according to the European Union Directive criteria. Although intervention in the bakery industry has had little to no effect [104], installation of engineering controls and implementation of personal protective equipment programs in animal feed workers exposed to phytase was shown to result in the immediate cessation of hypersensitivity symptoms [10]. Improvements in biotechnology have also included the encapsulation of some enzymes [105, 106] and proteins [107]. These engineering controls have been proposed to reduce occupational exposure to enzymes; however, encapsulation alone may not completely prevent enzyme-induced allergy and OA [108, 109]. To date, the detergent industry has implemented a derived minimal effect level (DMEL) of 60 ng m−3 for pure enzyme proteins [110]. Although this DMEL was provided as guidance by the ACGIH, other manufacturers have implemented their own occupational exposure guidelines (OEGs) for fungal enzymes such as α-amylase (5–15 ng m−3), lipase (5–20 ng m−3), and cellulase (8–20 ng m−3) [110]. In addition, the detergent industry has developed a medical surveillance program to identify and correct elevated exposures before occupational illnesses occur [101–103, 111]. As a result, the incidence of occupational allergy has dropped substantially [101–103]. Implementation of DMELs and OEGs will further assist in the reduction of occupational exposure. Reducing worker exposure to fungal enzymes in industry by the implementation of engineering controls and other allergen avoidance strategies will continue to mitigate personal exposure and further reduce the occupational health risk.
Acknowledgments
This work was supported in part by an interagency agreement with NIEHS (Y1-ES-0001). The findings and conclusions in this paper are those of the authors and do not necessarily represent the views of the National Institute for Occupational Safety and Health.
U. S. Department of LaborEmployment status of the civilian noninstitutional population, 1940 to date2010Washington, DC, USABureau of Labor Statistics2010, http://www.bls.gov/cps/cpsaat1.pdfFebruary 2011, http://www.healthypeople.gov/2020/topicsobjectives2020/overview.aspx?topicid=30ButcherBTSalvaggioJEOccupational asthmaJournal of Allergy and Clinical Immunology1986784 I5475563534048DutkiewiczJJablonskiLOlenchockSAOccupational biohazards: a reviewAmerican Journal of Industrial Medicine19881456056233067569LaceyJCrookBFungal and actinomycete spores as pollutants of the workplace and occupational allergensAnnals of Occupational Hygiene19883245155333067644LachowskyFLopezMOccupational allergensCurrent Allergy and Asthma Reports20011658759311892089PedenDReedCEEnvironmental and occupational allergiesJournal of Allergy and Clinical Immunology20101252S150S16020176257PetsonkELWork-related asthma and implications for the general publicEnvironmental Health Perspectives2002110, suuplement 456957212194889MappCEGenetics and the occupational environmentCurrent Opinion in Allergy and Clinical Immunology20055211311815764899BaurXEnzymes as occupational and environmental respiratory sensitisersInternational Archives of Occupational and Environmental Health200578427928615818503JensenADahlSShersonDSommerBRespiratory complaints and high sensitization rate at a rennet-producing plantAmerican Journal of Industrial Medicine2006491085886116917831VanhanenMTuomiTTiikkainenUSensitisation to enzymes in the animal feed industryOccupational and Environmental Medicine200158211912311160990SanderIRaulf-HeimsothMSiethoffCLohausCMeyerHEBaurXAllergy to Aspergillus-derived enzymes in the baking industry: identification of β-xylosidase from Aspergillus niger as a new allergen (Asp n 14)Journal of Allergy and Clinical Immunology199810222562649723670TarvainenKKanervaLTupaselaOAllergy from cellulase and xylanase enzymesClinical and Experimental Allergy19912156096151742654BaurXSanderIPoschARaulf-HeimsothMBaker’s asthma due to the enzyme xylanase—a new occupational allergenClinical and Experimental Allergy199828121591159310024232BaurXMelching-KollmussSKoopsFStraßburgerKZoberAIgE-mediated allergy to phytase—a new animal feed additiveAllergy2002571094394512269943DoekesGKammingaNHelwegenLHeederikDOccupational IgE sensitisation to phytase, a phosphatase derived from Aspergillus nigerOccupational and Environmental Medicine199956745445910472316QuirceSFernández-NietoMBartoloméBBombínCCuevasMSastreJGlucoamylase: another fungal enzyme associated with baker’s asthmaAnnals of Allergy, Asthma and Immunology2002892197202BaurXSauerWWeissWBaking additives as new allergens in Baker’s asthmaRespiration198854170723244911QuirceSFernández-NietoMEscuderoCCuestaJDe Las HerasMSastreJBronchial responsiveness to bakery-derived allergens is strongly dependent on specific skin sensitivityAllergy200661101202120816942570ElmsJFishwickDWalkerJPrevalence of sensitisation to cellulase and xylanase in bakery workersOccupational and Environmental Medicine2003601080280414504373BiaginiREMacKenzieBASammonsDLEvaluation of the prevalence of antiwheat-, anti-flour dust, and anti-α-amylase specific IgE antibodies in US blood donorsAnnals of Allergy, Asthma and Immunology2004926649653HoubaRHeederikDJJDoekesGvan RunPEMExposure-sensitization relationship for α-amylase allergens in the baking industryAmerican Journal of Respiratory and Critical Care Medicine199615411301368680668SmithTASmithPWRespiratory symptoms and sensitization in bread and cake bakersOccupational Medicine19984853213289876416LosadaEHinojosaMQuirceSSánchez-CanoMMoneoIOccupational asthma caused by α-amylase inhalation: clinical and immunologic findings and bronchial response patternsJournal of Allergy and Clinical Immunology1992891 I1181251730831BrismanJBelinLClinical and immunological responses to occupational exposure to α-amylase in the baking industryBritish Journal of Industrial Medicine19914896046081832939BaurXChenZSanderIIsolation and denomination of an important allergen in baking additives: α-amylase from Aspergillus oryzae (Asp o II)Clinical and Experimental Allergy19942454654708087658BrismanJLillienbergLBelinLÅhmanMJärvholmBSensitisation to occupational allergens in bakers’ asthma and rhinitis: a case-referent studyInternational Archives of Occupational and Environmental Health200376216717012733091SmithTAParkerGHussainTRespiratory symptoms and wheat flour exposure: a study of flour millersOccupational Medicine2000501252910795388BaurXDegensPOSanderIBaker’s asthma: still among the most frequent occupational respiratory disordersJournal of Allergy and Clinical Immunology199810269849979847440BrantABerrimanJSharpCThe changing distribution of occupational asthma: a survey of supermarket bakery workersEuropean Respiratory Journal200525230330815684295SmithTALumleyKPSHuiEHKAllergy to flour and fungal amylase in bakery workersOccupational Medicine199747121249136214WalusiakJHankeWGórskiPPałczyńskiCRespiratory allergy in apprentice bakers: do occupational allergies follow the allergic march?Allergy200459444245015005769BatailleAAntonMMollatFRespiratory allergies among symptomatic bakers and pastry cooks: initial results of a prevalence studyAllergy and Immunology1995277107702739BirnbaumJLatilFVervloetDSenftMCharpinJThe role of alpha-amylase in baker’s asthmaRevue des Maladies Respiratoires1988555195213263674HornerWEArmstrongMEl-DahrJPrevalence of IgE reactivities in mold-allergic subjects to commercially available fungal enzymesAllergy and Asthma Proceedings200829662963519173790StoraasTSteinsvågSKFlorvaagEIrgensAAasenTBOccupational rhinitis: diagnostic criteria, relation to lower airway symptoms and IgE sensitization in bakery workersActa Oto-Laryngologica2005125111211121716353405BernsteinJABernsteinDIStauderTLummusZBernsteinILA cross-sectional survey of sensitization to Aspergillus oryzae-derived lactase in pharmaceutical workersJournal of Allergy and Clinical Immunology199910361153115710359899MuirDCFVerrallABJulianJAMillmanJMBeaudinMADolovichJOccupational sensitization to lactaseAmerican Journal of Industrial Medicine19973155705719099359LaukkanenARuoppiPRemesSKoistinenTMäkinen-KiljunenSLactase-induced occupational protein contact dermatitis and allergic rhinoconjunctivitisContact Dermatitis2007572899317627646BrantAHoleACannonJOccupational asthma caused by cellulase and lipase in the detergent industryOccupational and Environmental Medicine200461979379515317923JohnsenCRSorensenTBLarsenAIAllergy risk in an enzyme producing plant: a retrospective follow up studyOccupational and Environmental Medicine19975496716759423581VanhanenMTuomiTNordmanHSensitization to industrial enzymes in enzyme research and productionScandinavian Journal of Work, Environment and Health1997235385391LoureiroGTavaresBPereiraCLundbergMChieiraCOccupational allergy to fungal lipase in the pharmaceutical industryJournal of Investigational Allergology and Clinical Immunology200919324224419610273Simon-NobbeBDenkUPöllVRidRBreitenbachMThe spectrum of fungal allergyInternational Archives of Allergy and Immunology20081451588617709917GowNAGaddGMThe Growing Fungus1995London, UKChapman and HallBanKKaiedaMMatsumotoTKondoAFukudaHWhole cell biocatalyst for biodiesel fuel production utilizing Rhizopus oryzae cells immobilized within biomass support particlesBiochemical Engineering Journal200181394311356369FickersPBenettiPHWachéYHydrophobic substrate utilisation by the yeast Yarrowia lipolytica, and its potential applicationsFederation of European Microbiological Societies Yeast Research200556-7527543QuirceSCuevasMDiez-GomezMLRespiratory allergy to Aspergillus-derived enzymes in bakers’ asthmaJournal of Allergy and Clinical Immunology1992906 I9709781281180BaldrianPFungal laccases-occurrence and propertiesFederation of European Microbiological Societies Microbiology Reviews2006302215242HornerWEReeseGLehrerSBIdentification of the allergen Psi c 2 from the basidiomycete Psilocybe cubensis as a fungal cyclophilinInternational Archives of Allergy and Immunology19951071-32983007542081SenDWileyKWilliamsJGOccupational asthma in fruit salad processingClinical and Experimental Allergy19982833633679543087van RooyFGBGJHoubaRPalmenNA cross-sectional study among detergent workers exposed to liquid detergent enzymesOccupational and Environmental Medicine2009661175976519687021ElmsJBeckettPGriffinPJob categories and their effect on exposure to fungal alpha-amylase and inhalable dust in the U.K. baking industryAmerican Industrial Hygiene Association Journal200364446747112908861NieuwenhuijsenMJHeederikDDoekesGVenablesKMNewman TaylorAJExposure-response relations of α-amylase sensitisation in British bakeries and flour millsOccupational and Environmental Medicine199956319720110448329SmithTALumleyKPSWork-related asthma in a population exposed to grain, flour and other ingredient dustsOccupational Medicine199646137408672792SanderINeuhaus-SchröderCRaulf-HeimsothMDoekesCHeederikDBaurXQuantification of the inhalable exposure to α-amylase in two bakeriesPneumologie19985284404439774870HeederikDAre we closer to developing threshold limit values for allergens in the workplace?Current Opinion in Allergy and Clinical Immunology20011218518911964688ElmsJRobinsonEMasonHIqbalSGarrodAEvansGSEnzyme exposure in the British baking industryAnnals of Occupational Hygiene200650437938416467434HoubaRvan RunPDoekesGHeederikDSpithovenJAirborne levels of α-amylase allergens in bakeriesJournal of Allergy and Clinical Immunology19979932862929058682FlindtMLHAllergy to α-amylase and papainThe Lancet19791813114071408BaurXFruhmannGHaugBRascheBReiherWWeissWRole of Aspergillus amylase in baker's asthmaThe Lancet198618471p. 43SkjoldTDahlRJuhlBSigsgaardTThe incidence of respiratory symptoms and sensitisation in baker apprenticesEuropean Respiratory Journal200832245245918417513MooreVCCullinanPSadhraSBurgePSPeak expiratory flow analysis in workers exposed to detergent enzymesOccupational Medicine200959641842319528331SkjoldTNielsenSCAdolfKHoffmannHJDahlRSigsgaardTAllergy in bakers’ apprentices and factors associated to non-participation in a cohort study of allergic sensitizationInternational Archives of Occupational and Environmental Health200780545846417021842CullinanPCookAJonesMCannonJFitzgeraldBNewman TaylorAJClinical responses to ingested fungal α-amylase and hemicellulase in persons sensitized to Aspergillus fumigatus?Allergy19975233463499140529BaatjiesRLopataALSanderIDeterminants of asthma phenotypes in supermarket bakery workersEuropean Respiratory Journal200934482583319443530PageEHDowellCHMuellerCABiaginiREHeederikDExposure to flour dust and sensitization among bakery employeesAmerican Journal of Industrial Medicine201053121225123220862699van KampenVMergetRBrüningTOccupational allergies to phytasePneumologie2008621270771019012225CasperRZacharisenMCFinkJNOccupational asthma secondary to enzymes used in cheese productionAllergy and Asthma Proceedings200829437637918702884KizkinOTurkerGHacievliyagilSSGunenHProteolytic enzyme sensitivity and decrease in respiratory function (a 10-year follow-up)International Archives of Occupational and Environmental Health200275644144412070641ShigechiHKohJFujitaYDirect production of ethanol from raw corn starch via fermentation by use of a novel surface-engineered yeast strain codisplaying glucoamylase and α-amylaseApplied and Environmental Microbiology20047085037504015294847MousdaleDMBiofuels: Biotechnology, Chemistry, and Sustainable Development2008Boca Raton, Fla, USACRC Press, Taylor and Francis GroupSandifordCPTeeRDNewman TaylorAJThe role of cereal and fungal amylases in cereal flour hypersensitivityClinical and Experimental Allergy19942465495577522943BrismanJBaker’s asthmaOccupational and Environmental Medicine200259749850212107305BaurXCzupponABSanderIHeating inactivates the enzymatic activity and partially inactivates the allergenic activity of Asp o 2Clinical and Experimental Allergy19962622322348835132VissersMDoekesGHeederikDExposure to wheat allergen and fungal α-amylase in the homes of bakersClinical and Experimental Allergy200131101577158211678858KimHYNahmDHParkHSChoiDCOccupational asthma and IgE sensitization to cellulase in a textile industry workerAnnals of Allergy, Asthma and Immunology1999822174178van KampenVMergetRBrüningTOccupational allergies to xylanasesPneumologie200458210310614961439LosadaEHinojosaMMoneoIOccupational asthma caused by cellulaseJournal of Allergy and Clinical Immunology19867746356393958392RansomJHSchusterMAllergic reactions to enzymes used in plant cloning experimentsJournal of Allergy and Clinical Immunology19816754124157229229VanhanenMTuomiTHokkanenHEnzyme exposure and enzyme sensitisation in the baking industryOccupational and Environmental Medicine199653106706768943831MergetRSanderIRaulf-HeimsothMBaurXBaker’s asthma due to xylanase and cellulase without sensitization to alpha-amylase and only weak sensitization to flourInternational Archives of Allergy and Immunology2001124450250511340334GuoZXuXNew opportunity for enzymatic modification of fats and oils with industrial potentialsOrganic and Biomolecular Chemistry20053142615261915999195CaballeroMLGómezMGonzález-MuñozMOccupational sensitization to fungal enzymes used in animal feed industryInternational Archives of Allergy and Immunology2007144323123917587859O’ConnorTMBourkeJFJonesMBrennanNReport of occupational asthma due to phytase and β-glucanaseOccupational and Environmental Medicine200158641741911351059HurGYShinSYYeYMNahmDHParkHSTwo cases of occupational rhinitis caused by biodiastase in hospital and pharmaceutical workersAllergy20076291096109717686115PauwelsRDevosMCallensLvan der StraetenMRespiratory hazards from proteolytic enzymesThe Lancet197818065p. 669BenitoMJConnertonIFCórdobaJJGenetic characterization and expression of the novel fungal protease, EPg222 active in dry-cured meat productsApplied Microbiology and Biotechnology200673235636516941178WardMDWDonohueMJChungYJHuman serum IgE reacts with a Metarhizium anisopliae fungal catalaseInternational Archives of Allergy and Immunology2009150434335119571566BelleriLBrunelliECrippaMGoliaMVanoniOAlessioLOccupational exposure to pectinaseAllergy2002578p. 755RougéPCulerrierRCampistronMAllergenicity of Hev b 13, a major esterase allergen in natural rubber latex (Hevea brasiliensis) allergy, does not only depend on its carbohydrate moietyMolecular Immunology201047487187719945164ShankarJGuptaPDSridharaSSinghBPGaurSNAroraNImmunobiochemical analysis of cross-reactive glutathione-S-transferase allergen from different fungal sourcesImmunological Investigations2005341375115773571ShankarJSinghBPGaurSNAroraNRecombinant glutathione-S-transferase a major allergen from Alternaria alternata for clinical use in allergy patientsMolecular Immunology200643121927193216430961ComminsSPSatinoverSMHosenJDelayed anaphylaxis, angioedema, or urticaria after consumption of red meat in patients with IgE antibodies specific for galactose-α-1,3-galactoseJournal of Allergy and Clinical Immunology2009123242643319070355HeederikDDoekesGNieuwenhuijsenMJExposure assessment of high molecular weight sensitisers: contribution to occupational epidemiology and disease preventionOccupational and Environmental Medicine1999561173574110658558BogdanovicJKoetsMSanderIRapid detection of fungal α-amylase in the work environment with a lateral flow immunoassayJournal of Allergy and Clinical Immunology200611851157116317088143ElmsJDennissSSmithMDevelopment and validation of a monoclonal based immunoassay for the measurement of fungal alpha-amylase: focus on peak exposuresAnnals of Occupational Hygiene2001452899511182422SanderINeuhaus-SchröderCBorowitzkiGBaurXRaulf-HeimsothMDevelopment of a two-site enzyme-linked immunosorbent assay for γ-amylase from Aspergillus oryzae based on monoclonal antibodiesJournal of Immunological Methods19972101931019502588KurzatkowskiWTörrönenAFilipekJGlucose-induced secretion of Trichoderma reesei xylanasesApplied and Environmental Microbiology1996628285928658702278SarloKControl of occupational asthma and allergy in the detergent industryAnnals of Allergy, Asthma and Immunology20039053234SarloKKirchnerDBOccupational asthma and allergy in the detergent industry: new developmentsCurrent Opinion in Allergy and Clinical Immunology2002229710111964756SchweigertMKMackenzieDPSarloKOccupational asthma and allergy associated with the use of enzymes in the detergent industry—a review of the epidemiology, toxicology and methods of preventionClinical and Experimental Allergy200030111511151811069558MeijsterTTielemansEHeederikDEffect of an intervention aimed at reducing the risk of allergic respiratory disease in bakers: change in flour dust and fungal alpha-amylase levelsOccupational and Environmental Medicine200966854354919366713AzevedoHSReisRLEncapsulation of α-amylase into starch-based biomaterials: an enzymatic approach to tailor their degradation rateActa Biomaterialia2009583021303019427418ItohTIshRIIMatsuuraSIEnhancement in thermal stability and resistance to denaturants of lipase encapsulated in mesoporous silica with alkyltrimethylammonium (CTAB)Colloids and Surfaces B2010752478482WörsdörferBWoycechowskyKJHilvertDDirected evolution of a protein containerScience2011331601758959221292977CullinanPHarrisJMNewman TaylorAJAn outbreak of asthma in a modern detergent factoryThe Lancet2000356924518991900LissGMKominskyJRGallagherJSMeliusJBrooksSMBernsteinILFailure of enzyme encapsulation to prevent sensitization of workers in the dry bleach industryJournal of Allergy and Clinical Immunology19847333483556366032BasketterDABroekhuizenCFieldsendMDefining occupational and consumer exposure limits for enzyme protein respiratory allergens under REACHToxicology2010268316517020026217TarloSMLissGMPrevention of occupational asthma—practical implications for occupational physiciansOccupational Medicine200555858859416314329
Fungal enzymes utilized in different industries and associations with occupational sensitization.
Industry
Fungal Enzyme
Characterized occupational allergen
Uncharacterized occupational allergen
Agriculture
Protease, lipase
Animal feed
α-amylase, cellulase, lipase, phytase, protease, and xylanase
Beta-glucanase*, endo-xylanase
Pulp and paper production
Cellulase, hemicellulase, lipase, and xylanase
Esterase*, laccase, lignin peroxidase, manganese peroxidase, pectinase*, and mannose
Waste management
Lipase
Esterase*, cytochrome P450, laccase, lignin peroxidase, manganese peroxidase, and monooxygenase
Biotechnology
α-amylase, cellulase, glucoamylase, hemicellulase, and protease